N34880Cessna 177B · 1974

On September 2, 2014, about 1230 mountain daylight time, a Cessna 177B, N34880, impacted terrain about 5 miles southeast of Neihart, Montana. The private pilot and one passenger sustained minor injuries, one passenger was seriously injured, and one passenger was fatally injured. The airplane was destroyed during the accident sequence and subsequent post impact fire. The airplane was registered to, and operated by, the pilot under the provisions of 14 Code of Federal Regulations Part 91 as a personal flight. Visual meteorological conditions prevailed for the flight and no flight plan had been filed. The flight originated from Great Falls International Airport (GTF), Great Falls, Montana at about 1200.

The pilot reported that prior to the flight he checked the weather, mentally calculated the airplane's weight and balance, and conducted a preflight inspection of the airplane. The takeoff and departure were uneventful. About 30 miles to the southeast of the airport the pilot descended so the passengers could take photographs of the canyon and an old train route. The pilot conducted a climbing about 360 degree turn to 7,500 feet. He flew along the western ridge of the canyon showing the passengers various landmarks. He continued south along the canyon when the canyon started to narrow and the terrain started to rise. The pilot initiated a climb when the airplane experienced a downdraft. The airplane then experienced a second downdraft and the pilot felt the airplane was a little too low. Unable to turn around between the narrow canyon walls he found a low spot in the trees and attempted to turn around. Despite the airplane's nose being up, the airplane would not climb. It started brushing trees and then it descended into the trees. The last tree impact abruptly turned the airplane before it impacted the ground. Almost immediately after impact the pilot observed fire which quickly engulfed the airplane.

The pilot reported that there were no anomalies with the airframe or engine at the time of the accident.

The pilot, age 55, held a private pilot certificate for airplane single-engine land issued October 25, 2013, and a third-class medical certificate issued February 6, 2013 with the limitation that he must have available glasses for near vision. The pilot had 118 total hours, 35 of which were in the accident aircraft make and model.

The four-seat, high-wing, fixed gear airplane, serial number 17702061, was manufactured in 1974. It was powered by a Lycoming IO-360 series, 180 horsepower engine, and was equipped with a McCauley controllable pitch propeller. Review of the airplane's logbooks indicated that the airplane's most recent maintenance inspection was an annual inspection that occurred on July 10, 2014. A review of the weight and balance data for the airplane revealed that the maximum gross weight is 2,500 pounds. The calculated weight of the airplane at the time of the accident was about 2,614 pounds, which placed the center of gravity outside (forward) of the envelope throughout the accident flight.

The nearest weather reporting station was GTF, approximately 45 miles northwest of the accident site. At 1253 the weather was reported as wind from 250 at 13 knots gusting to 19 knots, visibility 10 statute miles, clear skies, temperature 19 degrees C, dewpoint 3 degrees C, and an altimeter setting of 29.82 inches of mercury.

A non-official surface observation site was located about 2 miles southwest of the accident site at an elevation of 8,232 feet. That station reported gusty surface winds around the accident time with a 22 mph wind gust reported immediately following the accident time.

National Weather Service charts were used to analyze the area around the accident site. The surface analysis chart revealed a fairly active surface environment with a developing stationary front located east of the accident site, and a developing cold front west of the accident site. The accident site was located in an area indicative of gusty wind conditions. An upper air chart revealed a trough located directly over the accident site that would likely enhance vertical air mixing and an increased potential for turbulence. A North American Mesoscale model sounding was created for the accident site and the layer from the surface through 10,000 feet MSL was "absolutely unstable" which indicates wind magnitudes as high as 30 knots and gusty winds would be expected; updraft and downdrafts would be expected in mountainous terrain.

A Weather Research and Forecasting Model simulation was run to simulate the weather conditions surrounding the accident site at the accident time. As the flight progressed the airplane would have experienced turbulence and encountered downdrafts with a tailwind component at a velocity between 100-200 feet per minute. The accident flight would not have encountered an updraft until rising terrain south and east of the accident sight.

The four-seat, high-wing, fixed gear airplane, serial number 17702061, was manufactured in 1974. It was powered by a Lycoming IO-360 series, 180 horsepower engine, and was equipped with a McCauley controllable pitch propeller. Review of the airplane's logbooks indicated that the airplane's most recent maintenance inspection was an annual inspection that occurred on July 10, 2014. A review of the weight and balance data for the airplane revealed that the maximum gross weight is 2,500 pounds. The calculated weight of the airplane at the time of the accident was about 2,614 pounds, which placed the center of gravity outside (forward) of the envelope throughout the accident flight.

The airplane came to rest near the top of a ridge in a heavily wooded mountain pass. The wreckage path was about 82 yards long running downhill; there were many downed trees, and tree fragments throughout the debris path. The first identified point of impact was a topped tree that was about 30 feet tall. About 30 yards from the topped tree was the right side stabilator and a portion of a red beacon lens. Shortly thereafter were fragments of stabilator end caps, branches, and part of a wheel pant. Also in this immediate area was an about three foot section of the outboard right wing and the right wing tip with the strobe and green navigation light still attached. Beyond the outboard right wing was the left side stabilator. There was an increase in fully downed 3- to 4-inch in diameter trees that sustained a smooth diagonal slice. Immediately following those trees was the main wreckage, which came to rest upside down and was heavily burned. The main wreckage consisted of the vertical stabilizer and rudder, left wing, inboard right wing, the cabin area, and engine compartment.

An on-scene examination revealed no anomalies with the airframe or engine that would have precluded normal operations.

The cabin area sustained heavy thermal damage throughout; the propeller, throttle, and mixture controls were full forward and sustained heat damage. The instrument panel, avionics, and fuel selector were unidentifiable. Control continuity was established throughout the primary flight controls. The fuel system was mostly consumed by fire; however, the left wing fuel tank contained several gallons of fuel consistent with 100LL aviation gasoline.

The engine remained intact and sustained extensive thermal damage; it was unable to be rotated by hand. There was no evidence of catastrophic engine failure. The propeller blades were still secured to the propeller hub and both were bent aft.