N38171 is a 1977 Piper PA-32R-300. It is a fixed-wing single-engine aircraft with 7 seats, powered by a Lycoming TI0-540 SER rated at 310 horsepower. Its registration was cancelled in May 1977. Its standard airworthiness certificate was issued in Oct 2009. This page also carries 1 NTSB event.
FAA recordRegistered in St Louis, MO in 1983 · deregistered in 1977.
2009
1983
1977
On June 26, 2009, at 0904 central daylight time, a Piper PA-32R-300, N38171, registered to and operated by PropAire, Inc., of St. Louis, Missouri, and piloted by a private pilot, was substantially damaged when it struck a tree and impacted terrain shortly after taking off from Gaston's Air strip (3MO), Lakeview, Arkansas. Visual meteorological conditions prevailed at the time of the accident. The personal flight was being conducted under the provisions of Title 14 Code of Federal Regulations (CFR) Part 91, and no flight plan had been filed. The pilot and two passengers were fatally injured. A fourth passenger was seriously injured, and a fifth passenger sustained minor injuries. The cross-country flight was originating at the time of the accident, and was en route to Spirit of St. Louis Airport (SUS), St. Louis, Missouri.
According to Global Positioning System (GPS) data retrieved from the airplane, the pilot and his party departed Spirit of St. Louis Airport at 0647 on June 23, and arrived at Gaston’s Airstrip at 0703. They were planning to go fishing for the next three days.
According to Lockheed Martin records, the pilot telephoned the flight service station (FSS) on June 26 at 0815 and obtained a weather briefing for the return flight to SUS. He did not file a flight plan.
The pilot and his passengers were driven to the airstrip by a Gaston employee. The employee said the passengers “wore plastic bags on their feet” and “had luggage on their laps.” He thought the airplane was “overloaded” and the passengers “were tense, [but] maybe [it was] just the heat.” They also appeared to be “in a hurry to leave.” He said the engine “didn’t sound right before takeoff,” and the airplane “didn’t appear to lift very well.”
A Baxter County sheriff’s deputy took a recorded statement from the passenger who was seated in the right front seat. He said that just before takeoff, the pilot told him they were going to need the entire runway. He said the airplane lifted off at the end of the runway, dropped down into a shallow valley, touched the ground, and lifted off again. It touched down a second time, hit a tree, and “rolled” several times. He climbed over the pilot (he said he could tell he was dead), got out of the airplane, and went back to where his son was sitting. He said his son could move but was “screaming in pain.”
One witness who observed the takeoff said the airplane “came from runway with nose up (sic), possibly 30 percent,” and “was losing altitude.” Other witnesses saw the airplane lift off and disappear into a shallow valley. When it reappeared, it was in a slight climb, the wings were "wig-wagging" and the airplane was "porpoising." A witness who was fishing in a boat on the nearby White River said he heard the airplane take off and could see it through the trees. He could tell it “didn’t have much altitude.” Another witness fishing on the river said the airplane “sounded like it was barely moving. The plane was approximately 100 feet off the ground. The plane veered to the right. The back of the plane hit a tree (sheared left wing).”
The first 9-1-1 call was received at 0904.
The pilot, age 52, held a private pilot certificate with airplane single-engine land and instrument ratings, dated April 22, 1992. He also held a third class airman medical certificate, dated March 17, 2008, with no restrictions or limitations.
The second of the pilot’s two logbooks was recovered from the wreckage. It contained entries October 18, 1993, to June 23, 2009, and indicated that the pilot had logged the following flight times:
Total time, 673.8
Airplane single–engine land, 673.8
Piper PA-32R-300, 165.3
Pilot-in-command, 567.4
Dual instruction, 122.3
Cross-country, 512.9
Night, 71.3
Actual instruments, 100.1
Simulated instruments, 62.7
His most recent flight review was accomplished on March 20, 2009, in the accident airplane.
N38171 (s.n. 32R-7780392), and model PA-32R-300, was manufactured by the Piper Aircraft Corporation in 1977, and was owned and operated by PropAire, Inc., of St. Louis, Missouri. It was equipped with a Lycoming IO-540-K1G5D engine (s.n. L-16598-48A), rated at 300 horsepower, driving a Hartzell 3-blade, all-metal, constant-speed propeller (m.n. HC-C3YR-1RF).
According to the aircraft’s maintenance records, the last annual and 100-hour inspections of the airframe, engine, and propeller were accomplished on March 10, 2009, at a tachometer time of 2,107.91 hours. At that time, the airframe total time was 9,011.45 hours, and the engine total time since new and since major overhaul, which was done on May 11, 2000, was 8,390.50 hours and 2,107.91 hours, respectively. The propeller was overhauled on April 6, 1999, and dynamically balanced on February 24, 2004, at a tachometer time of 1,015.17 hours. The last IFR certification of the transponder, altimeter, encoder, and static system was on April 8, 2009.
The following Aviation Routine Weather Report (METAR) was recorded at Ozark (Baxter County) Regional Airport (BPK), Mountain Home, Arkansas, located 5 miles east of the accident site, at 0853:
Wind, calm; visibility, 6, haze; sky condition, clear; temperature, 27 C.; dew point, 23 C.; altimeter setting, 29.91 inches of Mercury; Remarks: sea level pressure, 1011.6 mb.
The following Aviation Routine Weather Report (METAR) was recorded at Marion County Regional Airport (FLP), Flippin, Arkansas, located 5 miles south-southwest of the accident site:
Wind, calm; visibility, 10; sky condition, few clouds 6,000 feet; temperature, 28 degrees C.; dew point, 22 degrees C.; altimeter setting, 29.91 inches of Mercury.
Witnesses described the weather at the time of take off as being hot, hazy, and muggy.
Using the field elevation of 479 feet, a temperature and dew point of 27 and 23 degrees C. (81 and 73 degrees F.), respectively, and an altimeter setting of 29.91 inches of Mercury, the pressure altitude was computed to be 489 feet, the density altitude was calculated to be 2,367 feet, and the relative air density was calculated to be 93.25 percent at takeoff from Gaston’s.
Gaston’s Airstrip (3MO) is located one mile south of Lakeview at coordinates 36 degrees, 20.55’ north latitude, and 092 degrees, 33.25’ west longitude. It is situated at an elevation of 479 feet msl. It has one runway: 06-24, 3,200 feet x 55 feet, turf. The grass runway was well manicured. The height of the grass on the runway was approximately 1 inch.
The on-site investigation commenced June 27 and terminated June 28, 2009.
The compass heading for runway 6 was 069 degrees and was 0.6 miles long (as measured by automobile odometer). The airplane wreckage was measured to be 0.7 miles past the end of the runway.
Examination of the accident site disclosed tire tracks in the tall grass, on a magnetic heading of 120 degrees, leading up to a barbed wire fence that had been torn down. Just beyond the fence was a large tree with chop marks consistent with propeller strikes. Most of the bark was missing. At the base of this tree were the airplane’s left wing and left rear cargo door. Beyond the tree, on a heading of 128 degrees and twisting to a heading of 179 degrees, was the twisted airplane wreckage. The nose was aligned on a heading of 097 degrees and the tail was aligned on a heading of 031 degrees, magnetic. Numerous personal effects were found scattered on the ground.
The fuel selector was photographed and compared with an exemplar. It was determined that it was positioned on the left main tank. The landing gear control was in the DOWN position, and the bellcrank was extended. The flap handle lay flat on the floor, and the actuator was in the UP position. Examination of the elevator trim jackscrew revealed 8 threads exposed. According to the Piper Aircraft representative, 0 threads equates to FULL NOSE DOWN, 5 threads equates to the NEUTRAL position, and 16 threads equates to FULL NOSE UP. The ELT (emergency locator transmitter) was found ARMED with a battery expiration date of June 2010. Further examination of the cockpit disclosed the following:
Alternate Air – CLOSED
Suction – 0
Autopilot – OFF
Door Seals – ON
Backup Radio Master – ON
Guard – OFF
Attitude Gyro Switch – ON
Guard – ON
Outside Air Temperature – 9 degrees F. (15 degrees C.)
Master Switch – OFF
Fuel Pump – OFF
Anti-Collision Light – OFF
Landing Light – OFF
Pitot Heat – OFF
Airspeed Indicator – 0
No. 1 Artificial Gyro Horizon – Inverted, 15 degrees left bank/30 degrees nose up
No. 2 Artificial Gyro Horizon – 90 degrees left bank
Directional Gyro – 255 degrees
Altimeter – 800 feet, 29.90 inches of Mercury
Vertical Speed – 500 fpm, UP
No. 1 OBS – 030 degrees
No. 2 OBS – 120 degrees
Left/Right Fuel – 0
Fuel Pressure – 0
Manifold Pressure – 30 inches of Mercury
Fuel Flow – 0
Magnetos – BOTH
ADF – 355 degrees HEADING, 085 degrees BEARING, 227kHz
Transponder – 1200 Mode C
Examination of the engine revealed oil in the crankcase. Thumb compression was obtained on all cylinders. The spark plugs were of normal coloration, and the fuel screen and servo and oil filter were clean. Both magnetos produced spark when turned by hand. All three propeller blades were bent aft midspan, and the tips were curled forward. There were 90-degree chordwise scratches on the cambered surfaces of all the blades,
An autopsy was performed on the pilot by the Arkansas State Crime Lab in Little Rock Arkansas. According to the autopsy report, death was attributed to “multiple traumatic injuries.” The manner of death was “accident.”
FAA Civil Aeromedical Institute (CAMI) performed a toxicological screen. According to CAMI’s report, there was no evidence of carbon monoxide or cyanide in the blood, and there was no evidence of ethanol in vitreous. Ibuprofen was detected in the blood. Ibuprofen is a non-steroid anti-inflammatory drug used for pain relief and fever reduction, and as an analgesic.
Attached to the airplane’s instrument panel was a Garmin 496 Global Positioning System (GPS) receiver. It had the capability of recording and saving flight data on a memory chip. The receiver was sent to NTSB’s Vehicle Recorder Laboratory in Washington, DC, for download. Attached to this report are pictorial representations of the accident flight. Below is the data from the accident flight:
Position Time Altitude Length Time Speed Course
N36 20.884 W92 33.627 09:55:52 573 ft
N36 20.881 W92 33.628 09:59:11 500 ft 13 ft 0:03:19 0 mph 193°
N36 20.874 W92 33.648 09:59:26 499 ft 112 ft 0:00:15 5 mph 246°
N36 20.856 W92 33.659 09:59:39 496 ft 124 ft 0:00:13 7 mph 206°
N36 20.854 W92 33.654 09:59:51 494 ft 31 ft 0:00:12 2 mph 111°
N36 20.855 W92 33.655 10:03:43 492 ft 9 ft 0:03:52 0 mph 329°
N36 20.858 W92 33.637 10:04:01 497 ft 88 ft 0:00:18 3 mph 077°
N36.20.872 W92 33.583 10:04:07 497 ft 279 ft 0:00:06 32 mph 073°
N36.20.903 W92 33.485 10:04:14 494 ft 514 ft 0:00:07 50 mph 068°
N36.20.953 W92 33.342 10:04:22 496 ft 0.1 mi 0:00:08 65 mph 067°
N36.21.011 W92 33.156 10:04:31 194 ft 0.2 mi 0:00:09 74 mph 069°
N36 21.071 W92 32.961 10:04:40 508 ft 0.2 mi 0:00:09 78 mph 069°
N36.21.121 W92 32.786 10:04:48 508 ft 0.2 mi 0:00:08 77 mph 070°
N36.21.133 W92 32.720 10:04:51 507 ft 333 ft 0:00:03 76 mph 077°
N36.21.124 W92 32.536 10:04:59 497 ft 0.2 mi 0:00:08 77 mph 094°
N36.21.086 W92 32.368 10:05:07 497 ft 0.2 mi 0:00:08 73 mph 106°
NOTE: The time of the receipt of the first 9-1-1 call is slightly different than the recorded GPS times.
Weight and balance was computed, to wit:
Basic Empty Weight 1/ 2,281 X = 188,137.42
Pilot and Front Passenger 2/ 397 X 85.5 = 33,943.50
Passengers (Center Seat, Aft Facing) 2/ 332 X 119.1 = 39,541.20
Passengers (Rear Seats) 2/ 143 X 157.6 = 22,536.80
Fuel (94 gal maximum) 3/ 564 X 93.6 = 52,790.40
Baggage (forward) 4/ 60 X 42.0 = 2,520.00
Baggage (aft) 4/ 79 X 178.7 = 14,117.30
Baggage 5/ 88 X 157.6 = 13,868.80
Takeoff weight from SUS 3,944 367,455.42
Maximum gross weight 3,600
Overweight at SUS takeoff 344
c.g. at takeoff from SUS 367,455.42/3944 = 93.17 in.
c.g. envelope = 91.4 in. FWD limit, 95 in. AFT limit
1/ Weight and Balance Revision, dated March 3, 2007
2/ Coroner’s Report: (LF) W. Langford, 197
(RF) D. Berkerle, 200
(LC) J. Ritz, 182
(RC) D. Berkerle, 150
(LR) D. Langford, 143
3/ 6 pounds/gallon, topped off prior to departure from SUS
4/ Baxter County Sheriff (88 pounds of scattered personal effects were collected and weighed)
5/ It is not known where the miscellaneous 88 pounds of personal effects were stored. These were the items scattered at the accident site and collected by the sheriff’s department. For computational purposes, they have been assigned the empty right rear seat arm (157.6).
According to PropAire’s maintenance officer, club members flight plan for 16 gallons per hour and 5 gallons for takeoff and climb. This equates to roughly 26 gallons (1.3 X 16 = 20.8 + 5 = 25.5) of fuel consumed on the flight from SUS.
Basic Empty Weight 2,281 X = 188,137.42
Pilot and Front Passenger 397 X 85.5 = 33,943.50
Passengers (Center Seat, Aft Facing) 332 X 119.1 = 39,541.20
Passengers (Rear Seats) 143 X 157.6 = 22,536.80
Fuel (68 gal) 408 X 93.6 = 38,188.80
Baggage (forward) 60 X 42.0 = 2,520.00
Baggage (aft) 79 X 178.7 = 14,117.30
Baggage 88 X 157.6 = 13,868.80
Takeoff weight from SUS 3,788 352,853.82
Maximum gross weight 3,600
Overweight at Gaston’s takeoff 188
c.g. at takeoff from Gaston’s 352,853.82/3788 = 93.15 in.
The performance charts found in the Pilot’s Operating Handbook were consulted. Based on a gross weight of 3,000 pounds, the computed flaps-up takeoff ground roll (paved, level, dry runway) would be approximately 1,700 feet, and the computed flaps-up takeoff distance over a 50-foot barrier (paved, level, dry runway) would be approximately 2,900 feet. According to PropAire, members assess 10 per cent (short grass) and 20 per cent (long grass) performance penalties when computing takeoff distances on grass or turf runways. Using these performance penalties, the computed flaps-up takeoff ground roll would be approximately 1,870 feet, and the computed flaps-up takeoff distance over a 50-foot barrier would be approximately 3,190 feet.
Using 25° of flaps for takeoff, the computed takeoff ground roll (paved, level, dry runway) would be approximately 1,210 feet, and the computed takeoff distance over a 50-foot barrier (paved, level, dry runway) would be approximately 1,700 feet. Applying the 10 per cent performance penalty, the computed takeoff ground roll and takeoff distance over a 50-foot barrier from a short grass runway would be 1,331 feet and 1,870 feet, respectively. The runway at Gaston’s was 3,200 feet long.
It was noted that Section 5, “Performance,” of the Piper PA-32R-300 Pilot’s Operating Handbook (p. 5-1, excerpted) states: “The performance charts are unfactored (sic) and do not make any allowance for varying degrees of pilot proficiency or mechanical deterioration of the aircraft. Effects of conditions not considered on the charts must be evaluated by the pilot, such as the effect of soft or grass runway surface on takeoff and landing performance. WARNING: Performance information derived by extrapolation beyond the limits of the charts should not be used for flight planning purposes.”
A guest at Gaston’s videotaped the takeoff and the footage was made available to NTSB. According to the videotape, the nose wheel came off the ground as the airplane was approximately one-third down the runway. It maintained this attitude throughout the takeoff roll and lifted off at the end of the runway. At that point, the runway dropped off and the airplane disappeared from sight. Moments later it reappeared, still in a nose high attitude, and the wings were “wig-wagging.”
The videotape was reviewed by PropAire officials. The following is an excerpt from their correspondence: “Based on reports of 4-6" grass, [the pilot’s] only hope to achieve takeoff speed would have been to keep the nose on the runway for almost 3/4ths of the runway length. With a nose high attitude, he actually never achieved flying speed, as evidenced by the speeds recorded by the [Garmin GPS] 496. His continuation of the takeoff put him on the back side of the power curve, 'hanging on the prop' in ground effect.
“Based on the video, he was either trying to horse it off the ground and most likely [paniced] at that point (about mid field), or the airplane itself may have contributed to the pitch up moment given the overweight and aft CG.”
No photos yet. This aircraft is no longer FAA-registered, so it can't be claimed for uploads.
No trips logged. This aircraft is no longer FAA-registered, so it can't be claimed to log trips.
No stories yet. This aircraft is no longer FAA-registered, so it can't be claimed to add one.