N5757CCessna 340A · 1980

On November 27, 2024, about 0005 central standard time, a Cessna 340A airplane, N5757C, sustained substantial damage when it was involved in an accident near Muskogee, Oklahoma. The pilot and one passenger sustained minor injuries, and three passengers were not injured. The airplane was operated as a Title 14 Code of Federal Regulations Part 91 personal flight.

The pilot reported that, before departing on the cross-country flight, the airplane was “topped off” with 100 low lead fuel, resulting in a total of 183 gallons onboard for the flight. The pilot performed a preflight inspection of the airplane at night, but he did not have his headlamp with him, only his cellular phone. The pilot reported that, when verifying fuel levels in the dark, he typically feels inside the fuel tank with his finger, but he recalled not doing that with the right main fuel tank before departing on the accident flight.

The pilot’s fuel calculations showed that the flight would require a total of 150 gallons of fuel. The airplane was equipped with two main fuel tanks, each with a total capacity of 51 gallons, of which 50 gallons was usable; two auxiliary fuel tanks, each with a capacity of 32 gallons (31.5 gallons usable each tank); and one left side locker fuel tank, which had a total capacity of 20.5 gallons (20 gallons usable).

A review of ADS-B data showed that the airplane departed from Mission Field Airport (LVM), Livingston, Montana, about 1840 on an instrument flight rules flight plan to the intended destination of Muskogee-Davis Regional Airport (MKO), Muskogee, Oklahoma.

The pilot reported a higher than usual fuel consumption rate during the first half of the flight, which was in instrument meteorological conditions (IMC). While operating in IMC, the pilot was operating the engines at 100° degrees rich of peak versus the normal peak engine gas temperature. Additionally, the pilot was operating the heater for the first half of the flight and then occasionally for the second half of the flight. The pilot reported that, while enroute, he transferred fuel from the auxiliary fuel tanks and the left side locker fuel tank to the main fuel tanks. After the “final transfer” was completed, the pilot calculated that there was adequate fuel remaining, including the required reserve fuel, to make the destination airport. However, he reported that, over Tulsa (about 50 miles from the destination airport), the indicated fuel levels were less than he expected.

Shortly after the pilot was cleared for a visual approach at the destination, the right engine lost total power, followed by the left engine. The pilot attempted to restart both engines to no avail. At the beginning of the loss of engine power sequence, the pilot reported that the left side of the airplane had about 30 lbs (about 4.84 gallons) of fuel remaining and the right side had about 30 to 35 lbs (about 4.84 to 5.65 gallons) of fuel remaining.

During the subsequent forced landing, the right wing impacted a permanent elevated static display on MKO property, a U.S. Air Force T-33A jet trainer, located about 3,350 ft northwest of the approach end of runway 13, and came to rest upright. The pilot and passengers egressed the airplane without further incident. The airplane sustained substantial damage to the fuselage and the right wing.

During an onsite examination, fuel blighting was not observed on the grass. The right main fuel tank and the right auxiliary fuel tank were separated from the right wing during the impact sequence and sustained damage. All other fuel tanks were found intact. All the fuel tank caps were found installed on their respective fuel tank. The fuel tank caps were removed to view the inside of the fuel tanks. Fuel was not observed in any of the fuel tanks. All the fuel tank bladders were found intact, and they were not collapsed. The left side fuel selector was found on the left main fuel tank. The right side fuel selector was found on the right auxiliary fuel tank. No signs of fuel leakage were observed on the airframe or on the two engines. During the recovery operation, no usable fuel was recovered from the airplane.

According to the Cessna 340A Pilot’s Operating Handbook and Federal Aviation Administration (FAA) Approved Airplane Flight Manual, the airplane has an optional fuel low level warning light system. This system provides a visual warning in the cockpit when the left main fuel tank or the right main fuel tank, or both, contain about 60 lbs (about 9.68 gallons) of fuel. The airplane was not equipped with this system, nor was it required to be.

The configuration of the airplane’s fuel system did not allow the transfer of fuel from an auxiliary fuel tank to either of the main fuel tanks; auxiliary fuel could only be provided to the engine on the same side as the auxiliary fuel tank, via the fuel selector. The fuel in a locker fuel tank was fed to the associated main fuel tank when the transfer pump was activated by the pilot.

The airplane was not equipped with a digital engine monitor or a digital fuel flow indicator system.

A review of the airplane maintenance records showed that the airplane’s most recent annual inspection was completed on October 3, 2023, at an airframe total time of 2,980.4 hours.

The FAA Pilot’s Handbook of Aeronautical Knowledge FAA-H-8083-25C discusses fuel tank quantity gauges and states in part:

The fuel quantity gauges indicate the amount of fuel measured by a sensing unit in each fuel tank and is displayed in gallons or pounds. Aircraft certification rules require accuracy in fuel gauges only when they read “empty.” Any reading other than “empty” should be verified. Do not depend solely on the accuracy of the fuel quantity gauges. Always visually check the fuel level in each tank during the preflight inspection, and then compare it with the corresponding fuel quantity indication.

The document also discusses fuel consumption rates and states in part:

The rate of fuel consumption depends on many factors: condition of the engine, propeller/rotor pitch, propeller/ rotor revolutions per minute (rpm), richness of the mixture, and the percentage of horsepower used for flight at cruising speed. The pilot should know the approximate consumption rate from cruise performance charts or from experience. In addition to the amount of fuel required for the flight, there should be sufficient fuel for reserve. When estimating consumption, you must plan for cruise flight as well as startup and taxi, and higher fuel burn during climb. Remember that ground speed during climb is less than during cruise flight at the same airspeed. Additional fuel for adequate reserve should also be added as a safety measure.