N6537CPiper PA-34-200T · 1978

On January 13, 2013, about 1145 eastern daylight time, a Piper PA-34-200T, N6537C, was destroyed after impacting Croatan Sound, following a missed approach to land at Dare County Regional Airport (MQI) Manteo, North Carolina. The private pilot was fatally injured and the passenger sustained minor injuries. The airplane was registered to and operated by a private individual. Instrument meteorological conditions prevailed, and an in-flight instrument flight rules flight plan was filed for the personal flight that was conducted under the provisions of Title 14 Code of Federal Regulations Part 91. The flight departed Sanford-Lee County Airport (TTA), Sanford, North Carolina at an undetermined time.

According to ARTCC transcripts, at 1114, the accident pilot requested an instrument flight rules clearance to MQI. The controller responded and provided transponder code 3636 and the MQI altimeter setting of 30.17 inches of mercury. The pilot read back the information to controllers. At 1615, the controller told the accident pilot that he was in radar contact and was cleared to MQI, and to maintain five thousand feet mean sea level (msl). At 1619 the accident pilot told the controller that he had the MQI weather report and that he was requesting the GPS approach to runway 05 at MQI. The controller then cleared the accident airplane to fly direct to ALGTR intersection. At 1627, the controller directed the accident pilot to cross ALGTR intersection at or above two thousand feet msl, and that he was cleared for the GPS runway 05 approach into MQI. In addition, the accident pilot was to report inbound from ROWZO intersection. The accident pilot acknowledged the instructions from the controller and the reduced visibility report of "2 or 3" miles from a pilot who landed just prior to the accident airplane. At 1633, the accident pilot reported inbound from ROWZO intersection and that he would cancel his IFR clearance when able, on the current radio frequency. At 1645 the ARTCC controller attempted to reach the accident airplane on the radio. No distress calls were received and no further transmissions from the accident airplane were overheard on the radio.According to a witness, who was a pilot that landed about 15 minutes before the accident airplane, the automated weather observing system (AWOS) was inaccurate. The AWOS was reporting 10 statute miles visibility and the landing pilot reported the visibility to be 4 statute miles in fog. After landing, the landing pilot overheard the air route traffic control center (ARTCC) ask the accident pilot if he overheard the report of reduced visibility. The accident pilot acknowledged the report from the landing pilot. The landing pilot then put his airplane in the hangar and turned on his portable radio to listen to the accident airplane.

The landing pilot added that the airplane descended out of the clouds too far down the runway to safely land. "Unbelievably," the accident pilot reported turning for the visual downwind leg. The landing pilot stated that the fog and lower cloud ceilings were even worse in the accident pilot's direction. He also added that he did not overhear the pilot report a missed approach to ARTCC.

According to the passenger in the accident airplane, the pilot performed all of the preflight inspections of the airplane and did not report any malfunctions that would have precluded normal flight operations. She stated that she visually observed the pilot remove the fuel caps and verify sufficient fuel for the flight.

The passenger stated that as they descended through the clouds on the instrument approach, the airplane appeared too far down runway 05 to safely land, but she could see the intersecting runways of 17/35 below them. The accident pilot then made a left turn and leveled off on a downwind leg at 410 feet msl, and reported entering the downwind leg on the common traffic advisory frequency (CTAF). The passenger further stated that they entered a left turn for the base leg for runway 05 and announced the same on the CTAF. The passenger added that the airplane entered the clouds, the pilot stated "uh oh," added power, and the airplane impacted the water. The passenger also stated that the engines were running normally before the impact with the water.

A synopsis of communications between Washington ARTCC and the accident airplane is contained in the public docket.

The pilot, age 49, held a private pilot certificate with ratings for airplane single-engine land, airplane multiengine land, and airplane instrument. Federal Aviation Administration (FAA) records show that his third-class medical examination was last updated on February 8, 2011. According to the pilot logbooks, the pilot received his instrument rating on August 18, 2011. The pilot's logbooks revealed 386.6 total flight hours, and a total of 17.4 actual instrument hours, before the accident flight.

The six-seat, low wing, retractable gear airplane, was manufactured in 1978. A standard airworthiness certificate was issued on August 15, 2011. The airplane was powered by a Continental TSIO-360 engine and a Continental LTSIO-360 engine. The airplane propellers and maintenance logbooks were not recovered from the wreckage due to water submersion. Review of an invoice and/or work order revealed that the airplane's most recent annual inspection was completed on March 26, 2012 at a tachometer time of 469.3 hours.

The MQI 1135 surface weather observation, located about 1 mile northeast of the crash location, reported wind calm, visibility 10 statute miles, overcast skies at 200 feet msl, temperature 15 degrees C, dew point 13 degrees C, and an altimeter setting of 30.15 inches of mercury. However, a pilot report for reduced visibility at 2 or 3 miles was received by ARTCC and transmitted to the accident pilot and other aircraft in the area.

The six-seat, low wing, retractable gear airplane, was manufactured in 1978. A standard airworthiness certificate was issued on August 15, 2011. The airplane was powered by a Continental TSIO-360 engine and a Continental LTSIO-360 engine. The airplane propellers and maintenance logbooks were not recovered from the wreckage due to water submersion. Review of an invoice and/or work order revealed that the airplane's most recent annual inspection was completed on March 26, 2012 at a tachometer time of 469.3 hours.

The airplane was recovered from the water about 1,000 yards to the southwest of the approach end of runway 05 at MQI. Postaccident examination of the airplane by FAA inspectors noted that the fuselage section remained intact with crushing damage to the fuselage nose, top, and sides. The empennage section was torn from the fuselage. The vertical stabilizer was intact and still connected to the left horizontal stabilizer. The right horizontal stabilizer was torn from the empennage section. Further examination of the recovered airframe and flight control system components revealed no evidence of preimpact mechanical malfunction.

The right and left wings were torn from the airplane, breached, and destroyed. Both wing flaps remained attached to the wings and corresponded to the cockpit selector, which was in the full down position.

The left and right engines were recovered from the water and sent to the manufacturer for further examination. On March 25 and 26, 2013, the engines were disassembled with oversight from a NTSB investigator. No preaccident mechanical malfunctions or failures were found with the engines. A detailed report of the engine examinations is contained in the public docket. Both propellers were not recovered from the water.

All three landing gear were destroyed and corresponded with the cockpit selector handle in the down position. Both fuel mixtures were full rich and both propeller rpm handles were full forward. The right throttle was full forward and the left throttle was about 1/2 inch from full forward, exhibiting contact from the instrument panel.

Flight control continuity was established to all of the flight controls and surfaces. The flight control cables were compromised in numerous locations and the separations exhibited signatures indicative of overload failure and or salvage team separation.

Examination of the pilot's altimeter revealed that the instrument was found set at 30.00 inches of mercury, 150 feet lower than the reported altimeter setting at the time of the accident. In an interview with the passenger, she stated that she remembers the pilot setting the altimeters before takeoff from TTA. She also added that the airplane altimeters were not reset before landing at MQI.

According to FAA Advisory Circular 60-4A "Pilot's Spatial Disorientation," "Surface references and the natural horizon may at times become obscured, although visibility may be above visual flight rule minimums. Lack of natural horizon or surface reference is common on over-water flights, at night, and especially at night in extremely sparsely populated areas or in low visibility conditions. A sloping cloud formation, an obscured horizon, a dark scene spread with ground lights and stars, and certain geometric patterns of ground lights can provide inaccurate visual information for aligning the aircraft correctly with the actual horizon. The disoriented pilot may place the aircraft in a dangerous attitude."

An autopsy of the pilot was performed on January 15, 2013 by the Office of Forensic Pathology - Brody School of Medicine at Eastern Carolina University, Greenville, North Carolina The cause of death was reported as asphyxia due to neck injuries and drowning.

The FAA's Civil Aerospace Medical Institute performed forensic toxicology on specimens from the pilot. The report stated that the test was negative for carbon monoxide and ethanol. Indomethacin of an undetermined amount was detected in the urine. Indomethacin is used to treat pain or inflammation caused by many conditions such as arthritis, gout, ankylosing spondylitis, bursitis, or tendinitis. Lorazepam was detected in the blood and urine. Lorazepam is a prescription benzodiazepine that is used for the management of anxiety disorders and for insomnia