N7192LGrumman American Avn. AA-5 · 1973

On August 1, 2020, at an unknown time, a Grumman American AA-5, N7192L, sustained substantial damage when it was involved in an accident near Marion County Airport (X35), Dunnellon, Florida. The private pilot was fatally injured. The airplane was operated as a Title 14 Code of Federal Regulations (CFR) Part 91 personal flight.

The pilot held a private pilot certificate with a rating for airplane single-engine land. According to the airport manager, the pilot texted his girlfriend at 1527 eastern daylight time and said he was going to "fly a couple laps" around the X35 traffic pattern. The pilot did not file a flight plan and was not in communication with air traffic control. When his girlfriend did not hear back from the pilot later that afternoon, she contacted the airport manager, who in turn notified law enforcement. A search was initiated, and the airplane was located the following morning less than 1 mile west of the airport in heavily wooded terrain. There was no post impact fire.

According to the airplane's co-owner, she and the pilot had recently purchased the airplane. She said it had not flown in 14 years and the airplane was "in pieces" when it was purchased. The unassembled airplane was transported to the pilot's home, where it was partially assembled by the pilot then moved to X35 where it was fully assembled. The pilot did not hold a Federal Aviation Administration (FAA)-issued mechanic certificate but was known to restore, build, and repair vehicles and boats. The co-owner, who is not a pilot, said the pilot performed a test-flight of the newly assembled airplane on July 14, 2020, and reported that some of the gauges were not working. She thought one of the gauges was a fuel gauge.

The airport manager said the pilot was a "staple" at the airport and liked to "tinker" with things. His goal was to get the airplane to a point where he could have an FAA-certificated airframe and powerplant mechanic perform an annual inspection. The airport manager said the pilot had flown the airplane a few times before the accident flight. On one flight, the engine sputtered and lost power, but the pilot was able to land safely back at the airport. The pilot told the airport manager he had a problem with the left fuel tank and one of the gauges was "acting up."

A friend of the pilot stated that the pilot had told him that he had an issue with one of the fuel gauges (could not recall which one), the fuel pump and there was a fuel leak with one of the fuel bladders. The friend thought the pilot had fixed those fuel problems, but he was not sure how that was done.

The airplane collided with several trees and came to rest inverted. All major components of the airframe were accounted for at the accident site. Both wings and their associated flap/ailerons sustained impact damage. The left and right fuel tanks were breached. Both horizontal stabilizers and respective elevators had separated from the airframe due to impact. It was noted that the tips of both elevators were secured to the airplane via duct tape. The rudder remained attached to the empennage. Extensive corrosion was observed to the elevators’ and rudder’s internal structure. Though there were several breaks in the flight control system due to impact forces, flight control continuity for each flight control surface was established to the cockpit area.

Examination of the engine revealed the carburetor sustained impact damage and partially separated from the engine. The fuel inlet fitting bore was fractured, and the fuel inlet fitting and hose separated from the carburetor. The fuel inlet fuel screen was not observed. The carburetor was disassembled, and the bowl contained about 1 teaspoon of water and no fuel. The presence of water was verified via the use of water finding paste. Corrosion was observed on the internal surfaces of the carburetor.

The engine-driven fuel pump was fractured, and the pumping section separated from the engine. The pump was partially disassembled and no damage to the rubber diaphragms were noted. However, the pump’s internal check valves and other interior surfaces were heavily corroded.

Debris was also observed in the hose between the auxiliary fuel pump and the engine driven fuel pump. Air was blown by mouth through the hose and a partial obstruction was noted. The hose fitting was removed, and additional rubber debris was noted in the hose consistent with rubber hose lining damage during fitting installation. The auxiliary fuel pump switch was found in the “on” position at the accident site. This is consistent with the airplane’s pilot operating handbook, which instructs the pilot to turn the pump on for takeoff and landing. There were no other pre-impact anomalies noted with the airframe or engine.

The airplane was equipped with two fuel tanks (one in each wing) that held a total of 38 gallons (37 gallons usable). The pilot purchased fuel at X35 on June 13, 2020 (18 gallons) and June 16, 2020 (5 gallons), for a total of 23 gallons.

A review of the airplane's maintenance records revealed that the last annual inspection was completed on August 18, 2001, at an airframe total time of 2,029.66 and a tachometer time of 1,920.66. At the time of the accident, the tachometer read 1,922.21, for a total 1.55 hours since the annual inspection that was done almost 19 years before.

The engine (a Lycoming O-320-E2G), which has an average fuel burn rate of about 5.2 gallons per hour, was last overhauled on March 31, 1996, and underwent an annual inspection on July 2, 1996 (a tachometer time was not provided in the logbook entry). There was no record of the engine being overhauled in the 23 years since it was last overhauled. According to the engine manufacturer, the engine should be overhauled within 12 calendar years of the date they first entered service or of last overhaul “...to mitigate engine deterioration that occurs with age, including corrosion of metallic components and degradation of non-metallic components such as gaskets, seals, flexible hoses and fuel pump diaphragms.”

The FAA requires the airplane and engine to undergo an annual inspection as per Title 14 CFR 91.409.

The pilot's last FAA third-class medical was issued on November 21, 2017 and expired at the end of November 2019. He did not report his flight hours at the time the medical certificate was issued, and his logbooks were not made available for review.