N843ACAmerican Champion Aircraft 8KCAB · 1999

On October 23, 2021, about 1440 central daylight time, an American Champion Aircraft 8KCAB airplane, N843AC, was destroyed when it was involved in an accident near Marengo, Wisconsin. The pilot and his passenger were fatally injured. The airplane was operated as a Title 14 Code of Federal Regulations Part 91 personal flight.

The pilot’s sister-in-law reported that she received a phone call from the pilot about 5 minutes before the accident, during which the pilot told her to wait outside because he intended to fly over her house. The airplane overflew her position multiple times at a low altitude before she saw the airplane “doing a loop” shortly before she heard the airplane crash.

The pilot’s sister-in-law used her mobile phone to capture several “live” photos of the airplane while it maneuvered near her house during the final minutes of the flight. These “live” photos consisted of several frames of video with sound to create a short movie clip. One of these movie clips showed the airplane as it flew over a residential yard at a low altitude, as shown in figure 1. Another movie clip showed the airplane in a steep nose-down descent in the moments before the accident, depicted in figure 2. A review of the sound spectrum extracted from the movie clip that captured the final descent determined the fundamental propeller blade passage was about 80 Hz, which corresponded to 2,400 rpm for the 2-blade propeller installed on the airplane.

Figure 1. Airplane flying low over the ground (still image extracted from a video that was recorded by a witness)

Figure 2. Airplane descending during final low altitude maneuver (still images extracted from a video that was recorded by a witness)

Another witness was driving when he saw the airplane flying “pretty low” about 200 - 400 ft above the ground. The witness stated that the airplane dove toward the ground while flying to the west before it “went back up going upside down” while flying to the south. The airplane then descended and crashed in a residential yard while flying north.

A postaccident review of the passenger’s mobile phone determined that it contained a video recording of the flight. The phone, which was hand-held by the passenger who was seated in the rear seat of the airplane, frequently changed its view throughout the recording. However, in general, the camera’s field of view was out of the airplane’s right-and-left rear seat windows.

The airplane’s general ground track in the vicinity of the accident location was constructed based on recovered video footage and is depicted in figure 3. The airplane’s bank angle with respect to the visible horizon was estimated for several turns, with each turn chronologically numbered 1 - 6 and annotated in figure 3. Additionally, the airplane’s maximum bank angle during each turn is listed in table 1.

Figure 3. The airplane’s estimated ground track in the minutes before the accident, with red numbers indicating where the bank angles were measured during each turn

Table 1. Estimated maximum bank angle during turns

Based on the passenger’s video recording, the final maneuver began with the airplane rolling into a wings-level attitude before it pitched up into slight climb for about 3 seconds. The pilot then pitched the airplane into a negative G maneuver during which the passenger stated “Whooooa.” About 2 seconds later, the pilot increased airplane pitch into a rapidly positive G maneuver. The pilot then rolled the airplane into a steep (at least 80°) left-wing-down bank before the camera view panned into the interior of the airplane and showed the rear control stick in a neutral roll and slightly nose-up pitch input. About a second later, the rear control stick showed a nose-up pitch input, which was quickly followed by a right roll input in addition to the nose-up pitch input. During the final 3 seconds of the flight, the airplane’s stall warning horn was audible, the passenger was laughing, and the pilot stated an expletive. The pilot maintained the slight nose-up pitch input with a moderate right roll input until the video concluded with the sound of the airplane impacting the ground. There was no video evidence that the passenger interfered with the airplane’s flight controls during the flight.

Based on available maintenance documentation, the airframe total time since new was 2,345.9 hours. The factory rebuilt engine and new propeller accumulated 16.9 hours since they were installed on the airplane on September 21, 2021. A review of the maintenance logbooks revealed no unresolved discrepancies or maintenance actions.

Based on available maintenance documentation, the airframe total time since new was 2,345.9 hours. The factory rebuilt engine and new propeller accumulated 16.9 hours since they were installed on the airplane on September 21, 2021. A review of the maintenance logbooks revealed no unresolved discrepancies or maintenance actions.

A postaccident examination determined the airplane’s right-wing leading edge impacted the roof of a house before the fuselage impacted the ground in a nose-down pitch attitude. The main wreckage came to rest in the backyard of the house on a north heading. The main wreckage consisted of the fuselage, empennage, engine, and propeller. Both wings separated from the upper fuselage during impact and were found about 20 ft north of the main wreckage.

All structural components and flight control surfaces were located at the accident site. Flight control cable continuity could not be established; however, all observed separations were consistent with impact-related damage.

The wreckage examination revealed no evidence of a preimpact mechanical malfunction or failure that would have precluded normal operation.

An autopsy of the pilot was completed at the request of the Dane County Medical Examiner, McFarland, Wisconsin. According to the autopsy report, the pilot died as result of blunt force injuries. From histology sections of the myocardium, the medical examiner reported the pilot had acute myocarditis of probable viral etiology; his postmortem nasopharyngeal swab sample was positive for SARS-CoV-2 RNA (the virus that causes COVID-19). No other significant natural disease was identified. Toxicology testing performed for the medical examiner’s office was positive for caffeine in the pilot’s pleural blood.

Federal Aviation Administration toxicology testing did not detect any carboxyhemoglobin, ethanol, or tested-for drugs.