N9312NPiper PA-28R-200 · 1969

On October 9, 2015, about 2056 eastern daylight time, a Piper PA-28R-200, N9312N, departed controlled flight following a total loss of engine power and collided with trees while on final approach to runway 10 at Savannah, Hilton Head International Airport (SAV), Savannah, Georgia. The private pilot and passenger were seriously injured and the airplane was substantially damaged. The airplane operated by a private individual under the provisions of 14 Code of Federal Regulations Part 91 as a personal flight. Night visual meteorological conditions prevailed and an instrument flight rules (IFR) flight plan was filed for the flight that departed Jacksonville Executive Airport at Craig (CRG), Jacksonville, Florida about 2001.

Due to their injuries, the pilot and passenger could not recall the immediate events leading up to the accident, or the accident itself.

According to flight service station records, the pilot telephoned the Miami Flight Service Station for a weather briefing at 1607, for the planned 3 hour, 15-minute flight from Miami Executive Airport (TMB), Miami, Florida, to SAV, with an estimated departure time of 1630. Flight Service reported visual flight rules conditions along the entire route of flight, with widely scattered convective activity south of Miami and near Okeechobee, but they would not interfere with the flight. Visibility was unrestricted and the winds aloft were from the northwest about 8 knots. The pilot filed an IFR flight plan for an altitude of 7,000 feet, airspeed of 125 knots, an endurance of 5 hours and an estimated enroute time of 3 hours and 15 minutes.

According to air traffic control (ATC) radar data, the flight departed TMB at approximately 1700. About 2 hours after departure, at 9,000 feet mean sea level, the passenger requested a rest stop. The pilot diverted to CRG, which was approximately 125 miles south of the intended landing airport of SAV. They landed at 1930 and remained on the ground for approximately 30 minutes.

The pilot then filed a new IFR flight plan from CRG to SAV and indicated an endurance of 3 hours with an enroute time of 1 hour. The pilot did not take on additional fuel at CRG and departed at 2000 EDT. After departure, the airplane made a left turn to the north and climbed to 6,900 feet. Air Traffic Control coverage tracked the airplane from TMB through CRG and SAV and showed that the entire route of flight was approximately 465 miles.

Approximately 30 miles south of SAV, the pilot began his descent. He was cleared to land on runway 10. The airplane crossed over the route 95 interstate approximately 6 miles south southwest of SAV at 2,200 feet and was vectored for a right base leg to final entry into the airport traffic pattern. He turned right on to a final leg at approximately 800 feet. Shortly after turning on to a final leg, a SAV air traffic controller noticed the low altitude and advised the pilot to check his altitude. There was no response. The airplane departed controlled flight; it collided with trees and impacted the ground 2,800 feet from the approach end of runway 10.

The pilot, age 64, held a private pilot certificate with ratings for airplane single-engine land and instrument airplane. His last flight review completed on June 16, 2015. He also held a third-class airman medical certificate issued May, 1, 2015. The pilot reported 1,550 hours of total flight time, with 454 of those hours in the same make and model as the accident airplane.

According to Federal Aviation Administration (FAA) records and the airframe manufacturer, the four-seat, low wing, retractable tricycle gear airplane, serial number 28R-35012 was manufactured in 1969. It was powered by a Lycoming, IO-360-CIC 200-hp engine and equipped with a Hartzell HC-C2HK constant speed propeller. The fuel system consisted of two, 25-gallon wing tanks, each located in their respective wing for a total fuel load of 50 gallons, of which 48 gallons were usable. The fuel selector valve, located on left side panel of the floor, had three settings, left tank, right tank and off. The airplane's most recent annual inspection was completed on October 18, 2014. At that time, the engine had been operated for about 195 hours since major overhaul. The airplane had flown about 90 hours, from the time of the last annual inspection, until the accident.

At the time of departure, flight service indicated that the entire route was VFR, with widely scattered convective activity, and unrestricted visibility for the filed route. Weather observations from TMB, were calm winds and 10 miles visibility with a temperature of 27 degrees C and a dew point of 23 degrees C. The altimeter setting was 29.97 inches Hg and winds aloft at 6,000 feet were from 310 degrees at 7 knots.

Along the route of flight, conditions at Melbourne (MLB) were, winds aloft at 6,000 and 9,000 feet were from 340 degrees at 7 knots and from 290 degrees at 8 knots respectively. Conditions at Jacksonville (CRG), Florida were winds from 050 degrees at 3 knots, 10 miles visibility. Winds aloft over Jacksonville, Florida at 6,000 feet were light and variable.

At SAV, winds were calm with 10 miles visibility and broken clouds at 18,000 feet. The temperature was 22 degrees C and dew point 19 degrees C. The altimeter setting was 30.03 inches Hg. According to the United States Naval Observatory, Sun and Moon Data, official sunset was at 1859 and end of civil twilight was 1924. The moonset occurred at 1718 and 10 percent of the moon disc would have been visible had the moon been above the horizon.

According to Federal Aviation Administration (FAA) records and the airframe manufacturer, the four-seat, low wing, retractable tricycle gear airplane, serial number 28R-35012 was manufactured in 1969. It was powered by a Lycoming, IO-360-CIC 200-hp engine and equipped with a Hartzell HC-C2HK constant speed propeller. The fuel system consisted of two, 25-gallon wing tanks, each located in their respective wing for a total fuel load of 50 gallons, of which 48 gallons were usable. The fuel selector valve, located on left side panel of the floor, had three settings, left tank, right tank and off. The airplane's most recent annual inspection was completed on October 18, 2014. At that time, the engine had been operated for about 195 hours since major overhaul. The airplane had flown about 90 hours, from the time of the last annual inspection, until the accident.

According to an FAA inspector who travelled to the accident site, the airplane and all major components were accounted for at the scene. The wreckage debris was localized to the immediate vicinity of the airplane. It came through the tree canopy in a steep nose down attitude, breaking off tree limbs before striking the ground and coming to rest on an agricultural feed trough. The tail empennage was twisted and bent approximately 45 degrees to the left. On the leading edge of the right stabilator, there was a 16 inch semicircular, fore to aft accordion crush damage.

The right wing separated from the fuselage at the wing root during the accident sequence. It exhibited span wise leading edge crushing and the right fuel tank was compromised. The left wing remained attached to the fuselage and was crushed up to the wing spar immediately outboard of the left fuel tank, which was also compromised. The outer 24 inches of wing were sheared off. Both main landing gear remained attached to their respective wings and were in the down position.

Both propeller blades remained attached to the hub and were uniformly bent slightly aft about 10 degrees and one blade was fractured 8 inches from the tip. The fractured blade near the hub cut 9 inches through the fiberglass engine cowl in a straight line front to back and neither blade exhibited twisting or curling.

The engine remained partially attached to the firewall. Many of the engine mounts were either broken or bent. The fuselage and cabin displayed damage consistent with a front end low speed impact, but the cockpit area was not compromised and retained much of its occupiable space. The engine showed little sign of damage.

The throttle and propeller were fully forward and the mixture was 75 percent forward. The fuel selector switch was on left tank. The master switch, tail anti-collision lights and fuel boost pump were in the on position. The FAA inspector reported that the site was absent of any odor or evidence of fuel. There was no fuel staining on the fuselage, wings or ground.

Examination of the recovered airframe and flight control system components revealed no evidence of preimpact mechanical malfunction. Examination of the engine and system components revealed no evidence of preimpact mechanical malfunction that would preclude operation. During the examination of the engine, the No. 2 cylinder showed a compression of 20/60. The rest of the cylinders showed nominal compression. The lower compression on the No.2 cylinder would not preclude engine operations.

At the time of the engine power loss, the airplane had flown about 3 hours, 30 minutes since it's initial departure from TMB, which included 2 takeoffs and climb to altitude. Review of performance data revealed that the engine consumed about 10 gallons per hour, not including fuel used during taxi, takeoff, and climb. Fueling records from October 3, 2015, the week before the accident, indicated the pilot had purchased 9.5 gallons of fuel at TMB, but no other confirmation from the pilot, passenger or any witnesses could confirm the airplane was fully fueled prior to the accident flight.